Opening Hour

Mon - Sun, 08:00 - 24:00

Call Us

+86-21-58386189

Improvements in Copper heap leaching by use of wetting agents

Improvements in Copper heap leaching by use of wetting agents

+

leaching of oxide copper ores with sulphuric acid and subsequent SX/EWtreatment. Several trials on the use of wetting agents in heap leaching of Chilean oxide copper ores have been successfully conducted at IME, Institute of Process Metallurgy Metal Recycling at the RWTH Aachen University in cooperation with BASF SE, Ludwigshafen. The trials have been realized in an 8column setup each with ...

Acidic leaching of potentially toxic metals cadmium ...

Acidic leaching of potentially toxic metals cadmium ...

+

A column leaching study, coupled with acid deposition simulation, was conducted to investigate the leaching of potentially toxic metals (PTM) from zinc smelting slag materials (SSM) after being incubated in an acid Alfisol for 120 days at room temperature. Two SSMs (SSMA: acidic, 10 yrs exposure wi .

Innovations in Copper: Mining Extraction: Producing ...

Innovations in Copper: Mining Extraction: Producing ...

+

Until recently, conventional acidleaching of copper was utilized as a means of recovering copper from lowgrade materials such as waste rock and flotation tailings and was conducted in dumps that were already in place. At least five factors have impeded the acceptance of leaching as a major commercial process: The lack of an efficient way of recovering metallic copper from solutions. The very ...

Leaching Copper Acidic

Leaching Copper Acidic

+

Leaching And Selective Copper Recovery From Acidic . Leaching and selective copper recovery from acidic leachates of trs marias zinc plant mg, brazil metallurgical purifiion residues. Read More; Investigation Of Copperi Sulphide Leaching In . leaching of copper i sulphide has been the subject of many investigations 2 6, including leaching under high pressure and atmospheric ...

Selective leaching process for the recovery of copper and ...

Selective leaching process for the recovery of copper and ...

+

In the first stage, 2 N of sulphuric acid was used to leach the dust, with pH values controlled at, and a solidtoliquid ratio of 1:10. The results indied that zinc extraction efficiency was higher than 95%. A selective acid leaching process was then used to recover the copper content of .

How copper dump leaching works

How copper dump leaching works

+

In copper dump leaching, runofmine ore is irrigated with acidic leaching solution to generate aqueous cupric ions for further processing. The very large size of the ore particles being leached, as much as two meters in diameter, should preclude any significant metal recovery. Dump leaching should not .

Leaching behavior of copper from waste printed circuit ...

Leaching behavior of copper from waste printed circuit ...

+

 · In this work, a Brønsted acidic ionic liquid, 1butyl3methylimidazolium hydrogen sulfate ([bmim]HSO4), was used to leach copper from waste printed circuit boards (WPCBs, mounted with electronic components) for the first time, and the leaching behavior of copper was discussed in detail. The results showed that after the pretreatment, the metal distributions were different with the particle ...

An investigation into the leaching behaviour of copper ...

An investigation into the leaching behaviour of copper ...

+

acid during the leaching of such ores, which can make the process uneconomical (Habashi, 1970, 1980; YouCai et al., 2013). Table 1 shows the acid consumption and estimated time to complete the dissolution of major carbonaceous materials in 10 g/L sulfuric acid solutions. It can be seen that for acid leaching, each ton of carbonate mineral (

Study of Copper Leaching from Mining Waste in Acidic Media ...

Study of Copper Leaching from Mining Waste in Acidic Media ...

+

The material evaluated for the extraction of Copper by leaching in acidic solutions comes directly from waste dumps in the mining district of Linares, Jaén. The mining activity of Linares was mainly focused on the extraction of Lead and in a smaller proportion the Silver from the galena argentiferous mineral present in the area. This mining activity was maintained for hundreds of years when ...

Automating and Optimizing Copper Heap Leaching Processes

Automating and Optimizing Copper Heap Leaching Processes

+

 · Alena opens describing the heap leaching process for copper: Copper ore is excavated from the ground, crushed and then spread in uniform layers on a pad. A slow trickle of sulfuric acid is distributed over the pile, where it percolates to the bottom and a collection point. The acid leaches out the copper, along with other minerals, which can be extracted chemically. This continuous process is ...

STUDIES ON THE CURING AND LEACHING KINETICS OF MIXED ...

STUDIES ON THE CURING AND LEACHING KINETICS OF MIXED ...

+

existing mathematical models of heap leaching. Sulfuric acid curing is a pretreatment to accelerate the extraction kinetics of copper ores and is widely used in copper operations. The curing process involves the addition of a highly concentrated sulfuric acid to the copper ore during agglomeration. Then, chemical reactions already begin prior to irrigation of the heap, transforming the initial ...

LEACHING KINETICS OF COPPER FROM CHALCOPYRITE .

LEACHING KINETICS OF COPPER FROM CHALCOPYRITE .

+

LEACHING KINETICS OF COPPER FROM CHALCOPYRITE CONCENTRATE IN NITROUSSULFURIC ACID Ozge GOK*, Corby G. ANDERSON**, Gorkem CICEKLI*, E. Ilknur COCEN* * Mining Engineering Dept., Faculty of Engineering, Dokuz Eylul University, Izmir, 35160, Turkey; email: )

A STUDY OF LEACHING OF COPPER OXIDE ORE BY SULPHURIC ACID

A STUDY OF LEACHING OF COPPER OXIDE ORE BY SULPHURIC ACID

+

sulphuric acid solution was used and 5 g of the ground copper oxide ore with a solid to liquid. ratio of 13%. Leaching parameters such as leaching time from – 4 h, pH range – 4 ...

Selective Copper Recovery by Acid Leaching from Printed ...

Selective Copper Recovery by Acid Leaching from Printed ...

+

Keywords: copper; selective recovery; acid leaching; PCBs waste sludge 1. Introduction The high demand for electronic products in moder n life has rapidly expanded the production of printed circuit boards (PCBs), resulting in the release of a massive amount of unwanted solid and liquid wastes containing hazardous materials [1]. Manufacturing PCBs is a complied multistage process, using a ...

Hydrometallurgical Recovery of Metals from Large Printed ...

Hydrometallurgical Recovery of Metals from Large Printed ...

+

 · Optimizing acid leaching of copper from the wastewater treatment sludge of a printed circuit board industry using factorial experimental design Usarat Thawornchaisit, Kamalasiri Juthaisong